陕西省通村公路建设组建县级通村公路建设试验室 [复制链接]

各设区市、杨凌示范区交通局：ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
      为加强全省通村公路建设试验检测工作，为工程建设提供科学、真实、可靠的试验检测数据，及时对工程质量进行控制，根据焦方群副厅长在全省通村公路建设视频会议的讲话精神。要求各县（区）交通局尽快组建试验室，现就有关事项通知如下：ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
       一、基本要求ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
       一）人员ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
       1.从事试验检测的工作人员要有良好的职业道德和高度的工作责任心，要有较强的专业技能和试验检测工作经验。ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
       2.通村公路建设临时试验室的人数必须保证5人以上，其中试验室主任1名，试验员2名，试验工2名。试验室主任应具有公路桥梁类中级以上职称（含中级），持有厅公路工程试验检测工程师及以上上岗证，在类似工程中从事实验工作三年以上，具有较高的理论水平和丰富的施工实践。试验员应从事试验工作二年以上经验，具有熟练的试验操作技能和丰富试验工作知识。ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
      二）仪器设备ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
       1.县级通村公路建设试验室的试验检测仪器、设备分为土工类、材料类、混凝土类、沥青类，具体仪器设备、型号、数量详见附表1。ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
       2.所有设备均应认真的进行调试、安装，确保使用性能良好，并备有充足的零备件和试验耗材。ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
       3.压力机、振动台和自动标准击实仪等仪器均应埋设水泥砼基座，并用地脚螺栓稳固连接。ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
       4.各类试验检测仪器的精度应满足规范规定的要求。并经过权威部门标定。ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
      三）试验室环境条件ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
      1.县级通村公路建设试验室应分室，应有标准水泥、砼操作室、养护室、土工室、沥青室、办公室。操作间和办公室需分开，试验室面积应满足附件2要求。ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
      2.各操作间应明亮、防尘，并操持清洁，各室的工作台应稳固，仪器摆放整齐。ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
      四）试验室管理制度ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
      1.试验室应设置组织机构框图。所有人员都要挂牌上岗。ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
      2.试验室应建立完整的管理制度及质量保证体系，管理制度、岗位职责、各种操作规程应齐全，并张贴上墙。ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
      3.试验室必须建立试验、检测台帐和主要仪器运转、校核、维修等各类台帐以及温度、湿度等记录。ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
      二、县级通村公路建设试验室建成后，由各市公路工程质量监督站按上述标准和要求进行验收，并颁发资格证书。ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
      三、县级通村公路建设试验室主要服务于各市县交通管理部门对通村公路的检查监督工作，不能代替施工单位试验室。对于大捆项目或较大项目，施工单位必须建立独立的试验室。ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
      四、根据省厅要求，省通村办对各县已建成试验室进行一次全面检查；检查合格后上报省厅，并给予适当补助。ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
      附件1.县级通村公路试验室仪器设备一览表ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
            2.县级通村公路建设试验室环境建设基本要求表ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
附件1ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð

县级通村公路试验室仪器设备价格一览表ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð

表1ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð

类别ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	名称ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	型号ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	技术参数ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	数量ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
土工类ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	土壤筛ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	Φ200双冲ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	孔径0.074-60mm，十一节ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1套ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	灌砂桶ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	Φ150ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	玻璃塑钢制灌砂桶Φ150、ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð 标定罐Φ150×Φ150ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	2套ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	土工多功能击实仪ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð （轻重两用）ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	DJY-Ⅱü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	气动锤重4.5kg（重型）ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð 2.5kg（轻）击锤落高450mm（重型）300（轻）ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð 锤击频率30次/分ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	干燥箱（数显）ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	101-3ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	300°C，工作尺寸ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð 80×80×100精度≤±1°Cü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	电子天平ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	JD2000-2ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	2000g/10mgü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	万分之一天平ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	抗压试模ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	Φ150mm×Φ150mmü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	6个ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	手动脱模器ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	TYT-3ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	配10T千斤顶，可脱各种模ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	路面强度试验仪ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	LQY-100Dü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	手动：任意制ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1套ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	铝盒ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	中ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	12个ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
砂石材料类ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	砂石筛ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	Φ200双冲ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	筛孔0.16-10ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1套ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	容积升ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	通用ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1、3、5、7、10、ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð 15、20、30升ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1套ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	砂漏斗ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	针片状规准仪ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	不锈钢ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	水泥混凝土集料用ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1付ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	集料压碎值仪ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	路面集料用，含捣棒及标定罐ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1套ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð

ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð

ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð
ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð

县级通村公路试验室仪器设备价格一览表ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð

ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð

类别ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	名称ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	型号ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	技术参数ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	数量ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
水泥类ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	雷氏煮沸箱ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	FZ-31A、ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð CF-Bü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	容积30L保温时间3h、ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð 加热功率4KW，不锈钢内胆ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	水泥标准稠度凝结ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð 时间测定仪ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	通用ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	滑动重量300±2gü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	水泥净浆搅拌机ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	NJ-160、ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð SS-160Bü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	公转慢625r/min、自转慢140ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð ±5r/min、快285±10r/minü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	水泥新标准胶砂ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð 搅拌机ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	JJ-5、ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð XJ-202-Aü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	搅拌叶宽135mm、锅5L、ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð 电机0.55/0.37千瓦ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	标准养护箱ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	40Bü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	李氏比重瓶ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	250mlü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1个ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
混凝土类ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	60升混凝土卧轴式ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð 搅拌机ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	60ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	60升，滚筒式搅拌ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	电动混凝土振动台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	ZH·DG-80ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	振动时间预知，地磁吸附，ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð 6个试模ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	坍落度仪ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	标准ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	砼坍落度桶及标尺ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1套ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	混凝土抗折试模ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	150×150×550ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	3套 ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	混凝土抗压试模ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	3套ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	30kg电子天平ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	ES30K-15ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	30kg/0.5kgü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	200T压力机ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	YE-2000Dü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð NYL-2000Dü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	最大荷载2000KNü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð 分柄档：0～800ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
沥青类ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	沥青抽提仪ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	CCT-1ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	路面取芯机ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	HZQ-150Bü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	含Φ50、Φ100钻头及ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð 连接件、涨紧件ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
	弯沉仪ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	5.4Mü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	铸铝、折叠式，配成量百分表ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	1台ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð

ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð

附件2ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð

县级通村公路试验室环境建设基本要求ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð

                                                       ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð

名  称ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	功   能ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	使用面积ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	环境及其他要求ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
办公室ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	人员办公 ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	不少于10m2ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	满足办公要求ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
混凝土室ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	水泥试验、混凝土试验ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	不少于10m2ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	满足办公要求ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
养护室ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	试件养护ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	不少于10m2ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	满足办公要求ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
沥青室ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	沥青试验ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	不少于10m2ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	满足办公要求ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð
土工室ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	土工实验ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	不少于15m2ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð	满足办公要求ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q Õð

ü¥ø2Wë²ê“bbs.3c3t.comÊKw›Q…Õð