陕西省通村公路建设组建县级通村公路建设试验室 [复制链接]

各设区市、杨凌示范区交通局：m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
      为加强全省通村公路建设试验检测工作，为工程建设提供科学、真实、可靠的试验检测数据，及时对工程质量进行控制，根据焦方群副厅长在全省通村公路建设视频会议的讲话精神。要求各县（区）交通局尽快组建试验室，现就有关事项通知如下：m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
       一、基本要求m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
       一）人员m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
       1.从事试验检测的工作人员要有良好的职业道德和高度的工作责任心，要有较强的专业技能和试验检测工作经验。m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
       2.通村公路建设临时试验室的人数必须保证5人以上，其中试验室主任1名，试验员2名，试验工2名。试验室主任应具有公路桥梁类中级以上职称（含中级），持有厅公路工程试验检测工程师及以上上岗证，在类似工程中从事实验工作三年以上，具有较高的理论水平和丰富的施工实践。试验员应从事试验工作二年以上经验，具有熟练的试验操作技能和丰富试验工作知识。m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
      二）仪器设备m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
       1.县级通村公路建设试验室的试验检测仪器、设备分为土工类、材料类、混凝土类、沥青类，具体仪器设备、型号、数量详见附表1。m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
       2.所有设备均应认真的进行调试、安装，确保使用性能良好，并备有充足的零备件和试验耗材。m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
       3.压力机、振动台和自动标准击实仪等仪器均应埋设水泥砼基座，并用地脚螺栓稳固连接。m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
       4.各类试验检测仪器的精度应满足规范规定的要求。并经过权威部门标定。m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
      三）试验室环境条件m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
      1.县级通村公路建设试验室应分室，应有标准水泥、砼操作室、养护室、土工室、沥青室、办公室。操作间和办公室需分开，试验室面积应满足附件2要求。m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
      2.各操作间应明亮、防尘，并操持清洁，各室的工作台应稳固，仪器摆放整齐。m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
      四）试验室管理制度m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
      1.试验室应设置组织机构框图。所有人员都要挂牌上岗。m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
      2.试验室应建立完整的管理制度及质量保证体系，管理制度、岗位职责、各种操作规程应齐全，并张贴上墙。m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
      3.试验室必须建立试验、检测台帐和主要仪器运转、校核、维修等各类台帐以及温度、湿度等记录。m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
      二、县级通村公路建设试验室建成后，由各市公路工程质量监督站按上述标准和要求进行验收，并颁发资格证书。m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
      三、县级通村公路建设试验室主要服务于各市县交通管理部门对通村公路的检查监督工作，不能代替施工单位试验室。对于大捆项目或较大项目，施工单位必须建立独立的试验室。m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
      四、根据省厅要求，省通村办对各县已建成试验室进行一次全面检查；检查合格后上报省厅，并给予适当补助。m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
      附件1.县级通村公路试验室仪器设备一览表m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
            2.县级通村公路建设试验室环境建设基本要求表m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
附件1m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ

县级通村公路试验室仪器设备价格一览表m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ

表1m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ

类别m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	名称m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	型号m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	技术参数m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	数量m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
土工类m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	土壤筛m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	Φ200双冲m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	孔径0.074-60mm，十一节m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1套m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	灌砂桶m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	Φ150m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	玻璃塑钢制灌砂桶Φ150、m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ 标定罐Φ150×Φ150m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	2套m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	土工多功能击实仪m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ （轻重两用）m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	DJY-Ⅱm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	气动锤重4.5kg（重型）m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ 2.5kg（轻）击锤落高450mm（重型）300（轻）m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ 锤击频率30次/分m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	干燥箱（数显）m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	101-3m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	300°C，工作尺寸m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ 80×80×100精度≤±1°Cm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	电子天平m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	JD2000-2m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	2000g/10mgm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	万分之一天平m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	抗压试模m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	Φ150mm×Φ150mmm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	6个m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	手动脱模器m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	TYT-3m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	配10T千斤顶，可脱各种模m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	路面强度试验仪m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	LQY-100Dm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	手动：任意制m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1套m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	铝盒m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	中m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	12个m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
砂石材料类m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	砂石筛m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	Φ200双冲m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	筛孔0.16-10m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1套m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	容积升m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	通用m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1、3、5、7、10、m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ 15、20、30升m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1套m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	砂漏斗m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	针片状规准仪m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	不锈钢m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	水泥混凝土集料用m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1付m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	集料压碎值仪m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	路面集料用，含捣棒及标定罐m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1套m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ

m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ

m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ

县级通村公路试验室仪器设备价格一览表m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ

m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ

类别m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	名称m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	型号m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	技术参数m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	数量m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
水泥类m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	雷氏煮沸箱m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	FZ-31A、m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ CF-Bm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	容积30L保温时间3h、m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ 加热功率4KW，不锈钢内胆m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	水泥标准稠度凝结m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ 时间测定仪m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	通用m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	滑动重量300±2gm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	水泥净浆搅拌机m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	NJ-160、m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ SS-160Bm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	公转慢625r/min、自转慢140m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ ±5r/min、快285±10r/minm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	水泥新标准胶砂m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ 搅拌机m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	JJ-5、m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ XJ-202-Am}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	搅拌叶宽135mm、锅5L、m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ 电机0.55/0.37千瓦m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	标准养护箱m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	40Bm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	李氏比重瓶m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	250mlm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1个m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
混凝土类m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	60升混凝土卧轴式m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ 搅拌机m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	60m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	60升，滚筒式搅拌m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	电动混凝土振动台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	ZH·DG-80m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	振动时间预知，地磁吸附，m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ 6个试模m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	坍落度仪m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	标准m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	砼坍落度桶及标尺m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1套m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	混凝土抗折试模m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	150×150×550m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	3套 m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	混凝土抗压试模m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	3套m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	30kg电子天平m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	ES30K-15m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	30kg/0.5kgm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	200T压力机m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	YE-2000Dm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ NYL-2000Dm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	最大荷载2000KNm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ 分柄档：0～800m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
沥青类m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	沥青抽提仪m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	CCT-1m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	路面取芯机m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	HZQ-150Bm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	含Φ50、Φ100钻头及m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ 连接件、涨紧件m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
	弯沉仪m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	5.4Mm}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	铸铝、折叠式，配成量百分表m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	1台m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ

m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ

附件2m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ

县级通村公路试验室环境建设基本要求m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ

                                                       m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ

名  称m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	功   能m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	使用面积m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	环境及其他要求m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
办公室m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	人员办公 m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	不少于10m2m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	满足办公要求m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
混凝土室m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	水泥试验、混凝土试验m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	不少于10m2m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	满足办公要求m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
养护室m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	试件养护m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	不少于10m2m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	满足办公要求m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
沥青室m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	沥青试验m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	不少于10m2m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	满足办公要求m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ
土工室m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	土工实验m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	不少于15m2m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ	满足办公要求m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ

m}†HÊYv¾ïbbs.3c3t.comPLçûÙIÐkÕ